Ryobi Garden - Popular Questions, Answers, Tips & Manuals


Hi Jeffrey-
I found a youtube video regarding troubleshooting a generator with no spark.
https://www.youtube.com/watch?v=Wi5gTyyHUIU

Hope this helps.

I also found a link for the Ryobi Ryi 2300BT Owners Manual.

https://manuals.ttigroupna.com/system/files/9994/original/RYi2300BT_BTA_090930309_330_506_trilingual_05.pdf?2019

Ryobi Garden | 46 views | 0 helpful votes


Without more information, the best guess is that the piston is probably seized in the cylinder, this will not fix itself by adding oil now. It likely needs a new piston and/or rings and/or cylinder or shortblock assembly. You can google your model number for sources of repair parts. Depends what you find when you disassemble it, if you can get the piston out you may be lucky to get by with a new set of rings and honing the cylinder.
But it will be a batch of work for a $200 blower. May be worth it if you can do it yourself and the parts arent too much. Certainly a shop couldn't do it for less than the replacement price of the whole blower.

Ryobi Garden | 59 views | 3 helpful votes


Stating the obvious it is running too lean on the mixture screws, you may well need a special tool to do this, but you need to open ( anti clockwise ) the H screw on the carb about 10 minutes on a clock face, this will richen the mixture and aid acceleration.

Ryobi Garden | 124 views | 0 helpful votes


Fix Factor: EasyDuration: 25-30 minutesFrequency: As necessaryTools Required: Receptacle for draining fuel, Phillip's screwdriver, ratchet and socket set, Torx drivers, starter rope (or similar object), spark plug wrench or socket, adjustable pliers, long-nosed pliers, shop rags.

REPLACE STARTER CHORD:

Remove the rear cover.2. Remove the carburetor.3. Disconnect the clutch housing.4. Bind the engine.5. Remove the clutch drum.6. Remove the clutch.7. Remove the starter.8. Remove the starter handle.9. Remove the recoil pulley.10. Remove the starter rope.Installing the New Starter Rope11. Install the starter rope.Reassembling the Unit12. Install the recoil pulley.13. Install the starter handle.14. Reinstall the starter.15. Reinstall the clutch.16. Reinstall the clutch drum.17. Reinstall the spark plug.18. Reinstall the clutch housing.19. Reinstall the carburetor.20. Reinstall the rear cover.

FLYWHEEL REMOVAL:

Use long-nosed pliers to remove the washer from the shaft.

While applying steady upward pressure to the flywheel, firmly strike the end of the shaft with a rubber mallet until the flywheel breaks free. Several blows from the mallet may be necessary to free the flywheel from the engine assembly.

Ryobi Garden | 36 views | 0 helpful votes


check the muffler.see if the spark arrester is clogged

Ryobi Garden | 84 views | 0 helpful votes


This is just the return to tank pipe, it does not need to be in the fuel, just in the tank far enough not to leak out the top.

Ryobi Garden | 78 views | 1 helpful votes


Sounds like a fuel problem - have you tried using partial choke? At least, this might verify that you just have a fuel problem. The 4-stroke is not as temporemental as the 2-stroke, but worth checking a few simple things : Is there an obstruction in the fuel supply ? Is the fuel tank supposed to be vented - if so, is the vent blocked ? Is there some dirt in the fuel, leading to a blocked jet in the carburetor ? - if so, drain/empty the carburetor, clean sediment & ensure all jets are clear and refill whole system with clean fresh fuel : If the carburetor or any part of it is loose, there might well be an Induction air-leak ( which could impair the engine's intake of fuel ) : And (of course ) - Is the spark-plug badly "gapped" or fouled ? Try to isolate and eradicate in a methodical way, good luck !

Ryobi Garden | 57 views | 0 helpful votes


Check all filters going to and from gas tank.One could be partly plugged.Also Air filter.

Ryobi Garden | 58 views | 0 helpful votes


If the knob is stuck in the pushed in position it will just click , try and pull it out then unscrew it

Ryobi 30cc 17"... | 47 views | 0 helpful votes


06b6b378-bffc-4c24-8f00-10bffdb3a0ac-ekquliymz1b0kl13j1i4m1y0-4-0.png No. 20 is spark plug, hopefully this will help.

Ryobi Garden | 793 views | 0 helpful votes


i don't know. [stop - your mower may be under warranty and may qualify for free repairs. check with your owner's manual for a free number to call for information]. before working on it, make sure the battery is removed. consider turning it upside down to inspect the wheel. if there is no physical blockage stopping the wheel from turning, you could try spraying the bolt with WD40 or a few drops of motor oil. if the wheel turns, lubricate it again and do the same to the other wheels. if it does not turn, the wheel will have to be taken off.

Ryobi Garden | 27 views | 0 helpful votes


That leaves

dirty carburetor with blocked jets. After trying to start, is the plug wet?

faulty ignition coil. If you remove the plug and ground it to earth, (a metal part of the engine), and pull the starter, do you get a nice fat blue spark?

bad compression. You need a compression tester.

Ryobi Garden | 26 views | 0 helpful votes


Snapped it off did you?.... you and 10,000 other ryobi owners.

I purchased on eBay ($7 US, delivered, a few yrs ago). You pry off the remainder and the new one presses on.

Ryobi Garden | 33 views | 0 helpful votes


Found this previously posted:

Cut two separate pieces of string, about 7 ft. each.

Stick the end of the line in the hole on the inside of spool.

Wind clockwise onto spool, putting the line that is closest to the ground on first.

Once you have winded this piece on, lock the last 4 inches of line through the slits on spool.

Repeat process for second piece of line, locking the last 4 inches in slot opposite the other locked in piece.

Put the spool on the trimmer, feeding the end of lines through either hole on trimmer.

Before you push the spool all the way on, pull the strings out of the locked position. Put cap on and GO CRAZY!

Ryobi Garden | 30 views | 0 helpful votes


Try https://www.ryobitools.com/support/manuals You should be able to locate your trimmer here and download the manual that will provide the information.

Ryobi Garden | 23 views | 0 helpful votes

Not finding what you are looking for?
Ryobi Logo

4,348 questions posted

Ask a Question

Usually answered in minutes!

Top Ryobi Garden Experts

Nick Olsen

Level 2 Expert

196 Answers

Dennis Tokarzewski

Level 1 Expert

21 Answers

Wayne McNeil

Level 2 Expert

209 Answers

Are you a Ryobi Garden Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...