How to fix oven door seal - Ovens

Unlikely there would be no air spilling through the door seal because it is an oven and not a watertight compartment. An oven door seal needs to be hard wearing and able to withstand high temperatures and hot grease which limits the materials used, that and the fact few domestic oven doors actually latch these days but are held closed by springs meaning the pressure against the seal is relatively light which means the door, the shut and the seal must be manufactured to a high degree of accuracy and properly adjusted.

If the amount or air leakage is excessive perhaps the door could be adjusted or the seal replaced. Try asking around to find someone with a similar oven so you can compare...

One of the door hinges may have come off track at the base of the door. Need to release the clamp on both hinges and get the door out for inspection.

New hinge can be got from
Delonghi Male Oven Door Hinge

contact the dealer/ distributor in your area or contact the maker direct. You may be up for a new door as sometimes the glass is glued into the door for sealing purposes.

cleaning your oven door switch might help but I would consider replacing the switch. The switches are sealed and cleaning does not work well.
http://www.on-timeappliance.com/ovenrepair.html

If your Jenn-Air model JES9750AAW oven door is squeaking, especially when heated, it could be caused by a variety of factors. Here are a few suggestions for fixing the problem:

1. Check the hinges: Make sure that the hinges are not bent or damaged, and that they are securely attached to the door and the oven. Tighten any loose screws, and make sure that the hinges are properly aligned.
2. Lubricate the hinges: If the hinges are not damaged, try lubricating them again, using a high-quality lubricant specifically designed for oven door hinges. Some examples are silicone lubricant, white lithium grease, or PTFE spray lubricant. These lubricants are heat-resistant and can withstand high temperatures.
3. Check the door gasket: The door gasket is the seal that runs around the edge of the door and helps to keep the heat inside the oven. Make sure that the gasket is not damaged or worn, and that it is securely attached to the door. A damaged gasket can cause the door to not seal properly and cause the squeaking noise.
4. Check the door handle: Make sure that the door handle is securely attached to the door. If it is loose, it can cause the door to not sit flush against the oven and cause the squeaking noise.
5. Call for service: If none of the above solutions work, it may be necessary to contact a professional technician to take a look at your oven and diagnose the problem.

Hello, OVEN DOOR Oven Door

#1 -- Oven door liner
#2 -- Oven inner glass
#3 -- Oven door hinge
#4 -- Retainer, glass
#5 -- Bracket, handle
#6 -- Door glass seal, top
#7 -- Door glass seal, side
#8 -- Oven outer door glass
#9 -- Door handle
#10
Read more: http://www.appliancepartspros.com/bd_whirpool_oven_parts.aspx#ixzz0pj5Z78oi
http://www.appliancepartspros.com .
Hope this helps.
Thanks

I have a Zanussi ZDF290X which requires a new top oven seal. I have pulled the remainns of the old one out, but without dismantling the oven it seems impossible to fit the new seal. Any easy way of fixing this, please?

If you take the hinges off, you can fit some washers between the hinges and the door to make it close it further. Probably not as good as new hinges, but cheaper. 2mm of washers will close a 5mm gap

Don't buy Bosh. This is a common problem with them and they are not interested in a fix (ie a thinner door seal would help or adjustment to springs...