I have a 2002 Ford Explorer that runs rough at Idle (and has stalled 3 times while stopped) -once the engine is warm. It does not occur after starting, but only happens after the engie is warmed, especially after driving for a long distance. The RPM fluctuates as much as +/- 400 RPM or less. It has very high mileage, but until recently has run smooth.
SOURCE: runs rough
How long have you had this problem? It could just be a bad tank of gas. Other things to check:
1. fuel pump and filter
Could be running on only 5 cylinders due to
2. spark plugs/wires
3. plugged fuel injector
Any problems with electrical? Like lights dimming at same time as running rough?
4. could be bad alternator putting excessive load on engine.
SOURCE: rough idle when cold
This could possibly be a faulty engine coolant temperature sensor. these sensors are prone to failing.
SOURCE: ROugh idle
there are 2 things that usually cause this, one is a dirty intake idle control valve and the other is hard engine mounts, I would say that both most likely apply to your car. try cleaning the intake with the following procedure from Ford.
Here is the most common cause of surges and stalls and low idle rough idle, it is the idle speed control air-bypass valve and throttle valve (IAC for short), they get full of gunk over the miles and cause idle issues (stalls, low idle) like yours, Get a can of intake cleaner from any local parts store, not carb spray, intake cleaner, it is made by a company called CRC, remove the air intake hose to the engine, hold the idle high so the engine won't stall, then spray the can of cleaner into the intake while keeping the engine running, use at least 1/2 the can, shut down the engine and disconnect the battery for 5 minutes, then restart and complete a number of mixed driving cycles, town, freeway, stop and go etc., after a few days the problem will go away as the system will relearn to the clean intake.
SOURCE: rough Idle trough1500 RPM with trouble
A code P0303 may mean that one or more of the following has happened:
Possible Solutions
If there are no symptoms, the simplest thing to do is to reset the code and see if it comes back.
If there are symptoms such as the engine is stumbling or hesitating, check all wiring and connectors that lead to the cylinders (i.e. spark plugs). Depending on how long the ignition components have been in the car, it may be a good idea to replace them as part of your regular maintenance schedule. I would suggest spark plugs, spark plug wires, distributor cap, and rotor (if applicable). Otherwise, check the coils (a.k.a. coil packs). In some cases, the catalytic converter has gone bad. If you smell rotten eggs in the exhaust, your cat converter needs to be replaced. I've also heard in other cases the problems were faulty fuel injectors.
A. P0401 "Exhaust Gas Recirculation Flow Insufficient Detected" that there is not enough exhaust gas being admitted to the engine.
There are a number of things you can check, and others you need a scan tool to check.
What you can do is check for vacuum to the EGR valve. You can remove the EGR valve and see if it is stuck closed. Test it with a hand vacuum pump and see if it opens smoothly. Check the EGR valve orifice and make sure it is free and clear. Check and clean the EGR passages in the going to and from the EGR valve.
If this checks out, then the Differential Pressure Feedback EGR system will need to be scanned to check the EGR sensors and switches
A code P0301 may mean that one or more of the following has happened:
It can be issue
with IAC( idle air control valve) causing the problem.
There
are many other possibilities causing these idle issues. Engine idles rough.
There
are few help links with solutions to troubleshoot such idle issues.
I
suggest you refer the link below and follow
its troubleshooting details:------
Click
the link below:-----
-----------
http://schematicsdiagram.blogspot.in/2012/03/stumbling-and-stalling-at-idle-after.html
------------
http://technoanswers.blogspot.in/2012/01/1999-ford-f-150-idles-rough-and-quits.html
---------
http://repairhelpcenter.blogspot.com/2012/01/engine-stumbles-coming-off-idle-when.html
------------------
http://schematicsdiagram.blogspot.com/2011/12/erratic-idle-on-car.html
-----------
Cold start problem and vehicle shudder around 2500 to
3500 rpms
----------
http://repairhelpcenter.blogspot.com/2011/12/low-idle-when-cold-out-side.html
-----------
http://technoanswers.blogspot.com/2012/10/gmc-sonoma-stalls-and-idles-low.html
--------
http://schematicsdiagram.blogspot.com/2011/12/gmc-idle-air-control-iac-valve.html
-------------
http://repairhelpcenter.blogspot.com/2011/10/1996-camry-intermittent-engine-failure.html
------------
http://repairhelpcenter.blogspot.com/2011/10/engine-quits-at-idle.html
-----------
http://howtobyme.blogspot.com/2011/11/car-overheats-and-air-blows-hot-at-idle.html
---------
High
Idle Problem
http://repairhelpcenter.blogspot.com/2012/10/high-idle-problem.html
-------
http://schematicsdiagram.blogspot.com/2012/01/while-stop-engine-idles-like-cylinder.html
---------
http://technoanswers.blogspot.in/2012/02/idle-flair-is-noticed-on-car-rough-idle.html
--------
http://technoanswers.blogspot.in/2012/02/high-rpm-in-neutral-inconsistant-high.html
-------
http://schematicsdiagram.blogspot.in/2012/03/vehicle-stumbling-at-idle-and-shows.html
----------
http://technoanswers.blogspot.in/2012/03/rough-idlestaling-and-erratic-shifting.html
-----------
http://schematicsdiagram.blogspot.com/2012/01/while-stop-engine-idles-like-cylinder.html
---------
These
details will help.
Thanks.
http://howtobyme.blogspot.in/2012/01/2004-ford-freestar-van-idles-rough.html
---------
will not idle when cold?
http://technoanswers.blogspot.in/2012/02/ford-explorer-40-will-not-idle-when.html
----------
runs lean and idles rough?
http://technoanswers.blogspot.in/2012/02/ford-runs-lean-and-idles-rough.html
-----------
Engine stumbles coming off idle when warm?
http://repairhelpcenter.blogspot.com/2012/01/engine-stumbles-coming-off-idle-when.html
------------
Erratic idle on car?
http://schematicsdiagram.blogspot.com/2011/12/erratic-idle-on-car.html
----------
Low idle when cold out side?
http://repairhelpcenter.blogspot.com/2011/12/low-idle-when-cold-out-side.html
---------
Idle Air Control (IAC)
Valve Replacing?
http://schematicsdiagram.blogspot.com/2011/12/gmc-idle-air-control-iac-valve.html
-----------
Replace
Idle air control valve?
---------
Test
Idle Air Control (IAC) Valve?
-------
Idle
Air Control (IAC) Valve operation?
----------
Engine quits at idle?
http://repairhelpcenter.blogspot.com/2011/10/engine-quits-at-idle.html
------------
Car overheats and Air blows
hot at idle?
http://howtobyme.blogspot.com/2011/11/car-overheats-and-air-blows-hot-at-idle.html
------
While stop engine idles
like cylinder missing?
http://schematicsdiagram.blogspot.com/2012/01/while-stop-engine-idles-like-cylinder.html
---------
This will help.
Thanks.
http://howtobyme.blogspot.in/2012/01/2004-ford-freestar-van-idles-rough.html
---------
will not idle when cold?
http://technoanswers.blogspot.in/2012/02/ford-explorer-40-will-not-idle-when.html
----------
runs lean and idles rough?
http://technoanswers.blogspot.in/2012/02/ford-runs-lean-and-idles-rough.html
-----------
Engine stumbles coming off idle when warm?
http://repairhelpcenter.blogspot.com/2012/01/engine-stumbles-coming-off-idle-when.html
------------
Erratic idle on car?
http://schematicsdiagram.blogspot.com/2011/12/erratic-idle-on-car.html
----------
Low idle when cold out side?
http://repairhelpcenter.blogspot.com/2011/12/low-idle-when-cold-out-side.html
---------
Idle Air Control (IAC)
Valve Replacing?
http://schematicsdiagram.blogspot.com/2011/12/gmc-idle-air-control-iac-valve.html
----------
Engine quits at idle?
http://repairhelpcenter.blogspot.com/2011/10/engine-quits-at-idle.html
------------
Car overheats and Air blows
hot at idle?
http://howtobyme.blogspot.com/2011/11/car-overheats-and-air-blows-hot-at-idle.html
------
While stop engine idles
like cylinder missing?
http://schematicsdiagram.blogspot.com/2012/01/while-stop-engine-idles-like-cylinder.html
---------
This
will help.
Thanks.
http://howtobyme.blogspot.in/2012/01/2004-ford-freestar-van-idles-rough.html
---------
will not idle when cold?
http://technoanswers.blogspot.in/2012/02/ford-explorer-40-will-not-idle-when.html
----------
runs lean and idles rough?
http://technoanswers.blogspot.in/2012/02/ford-runs-lean-and-idles-rough.html
-----------
Engine stumbles coming off idle when warm?
http://repairhelpcenter.blogspot.com/2012/01/engine-stumbles-coming-off-idle-when.html
------------
Erratic idle on car?
http://schematicsdiagram.blogspot.com/2011/12/erratic-idle-on-car.html
----------
Low idle when cold out side?
http://repairhelpcenter.blogspot.com/2011/12/low-idle-when-cold-out-side.html
---------
Idle Air Control (IAC) Valve Replacing?
http://schematicsdiagram.blogspot.com/2011/12/gmc-idle-air-control-iac-valve.html
-----------
Replace Idle air control valve?
---------
Test Idle Air Control (IAC) Valve?
-------
Idle Air Control (IAC) Valve operation?
----------
Engine quits at idle?
http://repairhelpcenter.blogspot.com/2011/10/engine-quits-at-idle.html
------------
Car overheats and Air blows hot at idle?
http://howtobyme.blogspot.com/2011/11/car-overheats-and-air-blows-hot-at-idle.html
------
While stop engine idles like cylinder missing?
http://schematicsdiagram.blogspot.com/2012/01/while-stop-engine-idles-like-cylinder.html
---------
This will help.
Thanks.
http://repairhelpcenter.blogspot.com/2011/10/engine-quits-at-idle.html
------------
Car
overheats and Air blows hot at idle?
http://howtobyme.blogspot.com/2011/11/car-overheats-and-air-blows-hot-at-idle.html
------While stop engine idles
like cylinder missing?
http://schematicsdiagram.blogspot.com/2012/01/while-stop-engine-idles-like-cylinder.html
---------This will help.Thanks.
1,193 views
Usually answered in minutes!
×