20 Most Recent 2004 Saturn ION - Page 9 Questions & Answers


If you are using the AC or defroster, it is most likely the drain is clogged. When the AC runs, it will condense water on the evaporator. This is supposed to drain outside the car but if the drain is clogged it will back up and spill into the car. There should be a rubber drain tube on the evaporator box normally on the passenger side.

I do not have a clue as to cost.

2004 Saturn ION | Answered on Oct 28, 2013


Get locks checked out by a locksmith. You might have to replace that lock.

2004 Saturn ION | Answered on Oct 26, 2013


Yes the new tires will fit, but being the new tires are larger slight rubbing may happen when you turn sharp.

Btw, I’m available to help over the phone in case u need at https://www.6ya.com/expert/stephen_171aeeebef53a898

2004 Saturn ION | Answered on Oct 16, 2013


should not need to check it, but there is a level bolt on the side, you need to have the vehicle on level ramps to check it. they are hard to get undone.

2004 Saturn ION | Answered on Oct 09, 2013

2004 ION Manual

2004 Saturn ION | Uploaded on Oct 06, 2013


First test the master cylinder.with the engine off. Is the pedal firm. Is it holding pressure.If you say yes the master cyclinder is good. Now turn the vehicle on. does the pedal go to the floor.?.Now the ABS light doesnt have to be on to detect a problem ABS modules do fail. If it goes to the floor with the engine on and doesnt go to the floor with engine off. ABS motor module is no good. Why because the ABS motor pistons are not at it proper postion. Remember engine off we tested brakes without the ABS. Key on engine running we now test ABS. if it sink at this point the fix is a new abs module.Here the thing if you replace the module it will have to be flashed , the engine management will not communicate with it or recognize it






2004 Saturn ION | Answered on Sep 26, 2013


Pull the rubber boot for the wiring harness in the door hinge area. I would suspect cut wires. Have the same issue. Bad design. What else is new.

2004 Saturn ION | Answered on Sep 15, 2013


Have the cat converter check for failure and blocking the exhaust pipe. No codes will show . Test by hitting the cat converter with the heel of your hand and if it rattles get a new one.

2004 Saturn ION | Answered on Aug 21, 2013


Some times we overfill the system when charging it up if this is not the case then go back to the tech...oh and check your relays, they are under the hood in a fuse box and marked you will need a precision screw driver set to do this as you will need to carefully uncover the relays if you are not sure that they are making a clicking sound which indicates that they are still good. there are high and low speed relays or it could be your check valve acting up. In any event go back to the tech if not sure what to do.

2004 Saturn ION | Answered on Aug 16, 2013


Hose ? The drain valve on the lower radiator ? The water pump has what's called a weep hole built into it. When the water pump fails water weeps out of that little hole to let you know it's bad. I think the ion probably has the water pump onth the front of the engine under the plastic cover ? ( not sure on that ) if it is the water will leak from behind that plastic cover making it look like its coming from the area where the oil pan and that plastic meet. It could get blown around by the cooling fan making it look a lot worse that it is. Check the lower hose and all the other coolant hoses for cracks or leaks as well as the entire radiator area ( sides, top, bottom ) check your rad cap when its cool and be sure the rubber seal on the inside of the cap is good and not cracked or dry rotted. If it is then when the water gets hot and pressure builds in the rad it will leak. When its cold it may not.

2004 Saturn ION | Answered on Aug 09, 2013


2 amp on what?
You have to do a parasitic current test,
to find that out
Wiring diagram would be needed to see all
the possible circuits & their components

2004 Saturn ION | Answered on Aug 08, 2013


The fuse you replaced powers the hvac control. The run relay is powered by a 30amp fuse in the fuse box near the battery.
Is the relay getting power from that 30amp fuse ?

2004 Saturn ION | Answered on Jul 11, 2013


There is a guide on this site that tells you how to fix the passlock problem

http://moontaj.com/passlock

2004 Saturn ION | Answered on Jun 25, 2013


think ur fuel pump or pump regulator which is in engine area is failin

2004 Saturn ION | Answered on Jun 08, 2013


What have you checked so far ?
Is the check engine light staying on ?

2004 Saturn ION | Answered on Apr 21, 2013

Not finding what you are looking for?
2004 Saturn ION Logo

1,034 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

2003 Saturn ION
2003 Saturn ION

523 Questions

2006 Saturn ION
2006 Saturn ION

563 Questions

2005 Saturn ION
2005 Saturn ION

377 Questions

2007 Saturn Ion
2007 Saturn Ion

73 Questions

Top Saturn Experts

Marvin
Marvin

Level 3 Expert

85206 Answers

Jonah Oneal

Level 3 Expert

14092 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22484 Answers

Are you a Saturn Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

View Most Popular

Ion Saturn

  • Ion Saturn

Most Popular Question

car turns over but not start gave some

  • Cars & Trucks
Loading...