20 Most Recent
2003 Chevrolet Astro - Page 7 Questions & Answers
How to install fuel pump in chevy 2003 astro van
Go to the autozone website at autozone.com and register your vehicle. It's free and will give you access to an online repair manual for your vehicle. The procedures for changing the fuel pump should be available there. Sure hope this helped and best wishes.
Removing audio deck from 2003 Chevy Astro
It is very easy: With parking brake applied, shift to 1st gear, then
remove the dash panel that goes around the instrument cluster and the
stereo. Once the panel is off, you there is a black tab on both of
the side of the unit that you push down, and then pull the unit out.
To install an aftermarket deck, I recommend a specific wiring harness
adaptor, that you splice onto the connector included with the new deck
- so that you can reinstall the original one if/when you want to sell
the vehicle. If you don't, you have to cut the original harness wires,
and connect them in the correct orentation (which is tough, as there is
about 20 wires!)
The dash panel installs in the same way: shift to 1, then push into place.
Remove audio deck from 2003 Astro
It is very easy: With parking brake applied, shift to 1st gear, then remove the dash panel that goes around the instrument cluster and the stereo. Once the panel is off, you there is a black tab on both of the side of the unit that you push down, and then pull the unit out.
To install an aftermarket deck, I recommend a specific wiring harness adaptor, that you splice onto the connector included with the new deck - so that you can reinstall the original one if/when you want to sell the vehicle. If you don't, you have to cut the original harness wires, and connect them in the correct orentation (which is tough, as there is about 20 wires!)
Climate fan control not working
THE BLOWER AND RESISTOR ARE UNDER THE HOOD ON THE PASSENGER SIDE. CHECK FOR POWER AND GROUND AT THE RESISTOR CONNECTOR AND MAKE SURE THE FUSE IS NOT BLOWN.
Turn signal bulb broke in socket.
you'll be ok using needle nose pliers and a tin of wd 40 lube. but don't go too crazy with the stuff as it doesn't really like playing with terminals. but in this case use the straw attachment, for in between the outer casing of the bulb an the inner casing of the socket. leave for a couple of minutes then use the needle nose pliers, grip the casing of the bulb, inner and outer, push the bulb in with the pliers and then twist.
Goodluck
Jayce
Repalcement passenger ext. mirror
try this
http://cgi.ebay.com/ebaymotors/99-05-CHEVY-ASTRO-VAN-PASSENGER-MIRROR-GLASS_W0QQcmdZViewItemQQ_trkparmsZ72Q3a1205Q7c66Q3a2Q7c65Q3a12Q7c39Q3a1Q7c240Q3a1318Q7c301Q3a1Q7c293Q3a1Q7c294Q3a50QQ_trksidZp3286Q2ec0Q2em14QQhashZitem390026515821QQitemZ390026515821QQptZMotorsQ5fCarQ5fTruckQ5fPartsQ5fAccessories
might save $20 of the price of a whole assembly
Getting wires thru firewall
Start by looking under hood at firewall, there is usually rubber grommets for other items that you can use to poke in along side of them. I usually go in by speedo cable, steering shaft are, just make a small **** if you have to. Look around for one that is closest to your antennae mounting location. Cellular antennae, I guess stick on the glass type not available, or preferred?
After replacing the awd fluid,
You must use the upgraded/replacement AWD transfer case fluid from the dealer. The blue stuff. It has a friction modifier to address this issue. Mine had the same problem.
I need to replace a
Inside the Door By the Window there is a Black Panel torwards the Front of the Window. This panel Removes and Exposes the Screws that you need to Remove.
Climate control
There is a vacuum line that operates your selector switch, it is located under the hood, roughly in the center, up against the fire wall. If the line has leaks, your selector switch will not work and therefore all your blower doors will stay shut. Replace the line.
2005 Astro Van, when I
hello milford,
i don't think you can eliminate your problem, the door lock feature is being run by a single module and all doors are connected to it in parallel
so i you want that only the driver's side door would unlock as you put it in park, then you would isolate the rest of the doors to the module but will in turn not controll the rest for locking puposes.
you can not have both features. either control one door or controll all doors.
its your choice.
tnx for using fixya.
drcool
Astro van with random starting issue
this van or tipe of vehicles have a very coming problem with the injector assembly fault, if you ever get it to star make sure to see if you see any black smog coming from the exaust or if you notice like spending too much gas then that will be the proble and this part is not too chep to replace
Brake lights wont work
check if there is any voltage running to where the tail lights are. if not then you will need new light assembly.
Not finding what you are looking for?