Suzuki 2006 KingQuad 700 4X4 - Answered Questions & Fixed issues

Question edited for full make and model. Question moved from Computers. You must be Australian. You spell 'solenoid' like Australians speak it. :>D You have a dead short to earth. Incorrectly wired. Start checking with a multimeter set to Ohms. https://www.google.com/search?q=2006+Suzuki+KingQuad+700+replace+solenoid you are not alone! https://www.google.com/search?q=2006+suzuki+kingquad+700+blows+fuse ..

Sounds like you have a wire that is ALMOST broken or the insulation is worn off and grounding, or turning is pulling a wire loose from a connection. .. this type of problem is HARD to trace down sometimes... good luck

if its into aluminum I'd guess 11#. check suzuki atv forums for service manual

Personally i would check and see if you have any water in the carb before anything. this seems to be a common prob.

check the switches on your brake handle, broken wires, bad ground on the light.

Check the choke and fuel filter.

sounds like the timing belt broke. mechanic required

Have a load test done on the battery as a good battery should be 13.5 volts. There may be a dead cell that is not taking the load. Under crank load the voltage will drop off and there will not be enough current left to run the ignition system. The sprayer will use considerable less current that a starting engine so that is not an indication of a good battery

Hello Anom, I do need more information to truly help you. Has the ATV (??..engine size, carb, fuel inj., year,??..etc.).. been sitting for a while...the carb is probably in need of a simple cleaning (all internal passages), a new spark plug, clean/treat or replace the air filter will probably get it running! Please post more info. Thanks, Steve

modlife or goto suzuki theyll find it

are you low on oil?incorrect oil?

bad brake pads

Is it air or liquid cooled?Check fan, fan switch.

take off the horn unit power it direct if it works its ok, if not replace, next step wire a small bulb into the horn wires and press the button if it lights the switch is ok, if you have a circuit tester put one end on the battery ground and check for power in the horn wires if their is power there put the lead on battery positive and press the horn button if there is no power their the switch or wiring is faulty

Question edited for clarity, correct order and add maker. Question moved from Cars and Trucks to model category. Service manual https://www.manualslib.com/products/Suzuki-Kingquad-5901790.html ..

https://www.motosport.com/atv/oem-parts/suzuki/2004/eiger-400-4x4-auto/wiring-harness

https://www.polarisatvforums.com/threads/2006-polaris-sportsman-500-efi-not-getting-power-to-the-fuel-pump.191336/ This thread should help you.

Question edited for clarity.

SHI0206 - Kawasaki & Polaris Diesel UTV Starter

MFG Supply https://www.mfgsupply.com > shi0206 OEM Replacement This part is aftermarket equipment designed to replace the original manufacturer's part numbers specified here. ... 2014 Polaris Ranger Diesel. US$162.33

Ranger ETX Starter Replacement *UPDATE

Polaris Ranger Forum https://www.rangerforums.net > ... > General Discussion Sep 20, 2018 - Replacement: Carefully line up and press into place the new starter. Take top bolt and begin threading into hole but do not tighten. This will ... Starter Replacement - Polaris Ranger Forum Apr 29, 2018 Diesel ranger issues - Polaris Ranger Forum Nov 25, 2014 Starter Problems ' Polaris Ranger Forum Mar 16, 2023 Starter solenoid - Polaris Ranger Forum Jul 7, 2021 More results from www.rangerforums.net ..

It sounds like the battery is worn out. It is lacking Amps and Volts. Or the battery contacts are dirty or corroded causing a bad contact.

Question edited for clarity. Lots of help in the links, plus here is your service manual

2009 Polaris Outlaw 450 525 Service Manual.pdf

No-IP https://quads.ddns.net > service-manuals > 2009 P... PDF Refer to the "KTM Engine / Carburetion" section in the back of this service manual for carburetion maintenance details. Normal wear from engine vibrations ...

OUTLAW 525 IRS

Polaris https://cdn.polarisindustries.com > parts-manuals PDF Follow the recommended maintenance program outlined in your owner's manual. This program is designed to ensure that all critical components on your vehicle are. 210 pages https://www.google.com/search?q=2007+Polaris+Outlaw+525.+Where+is+the+fuse+location